焙烧炉烟气静电除尘工艺配置：来自焙烧炉的高温烟气首先进入蒸发冷却塔进行喷雾降温，其目的在于降低烟气的比电阻,将一部分气态焦油冷凝成液态焦油，控制烟气的温度在 90±5℃,使静电除尘器的净化效率达到最佳。冷却后的烟气经静电除尘器净化后，通过引风机送入烟囱排人大气。电捕焦油器捕集下来的焦油，经排放口定期排入贮油罐内。

静电除尘系统通常设置三条烟气通道：正常运行时,焙烧炉出口烟气温度小于 250℃，烟气通过喷雾冷却塔使温度降低到 90+5℃后进入电捕，净化后的烟气经排烟机和烟囱排入大气。冷却系统或电捕检修时，烟气经旁通烟道由排烟机引入烟囱后排入大气，此时关闭去冷却塔的烟道阀门、电捕与风机间的阀门以及直接通往烟囱的烟道阀门。当烟气温度高于 250℃、风机检修或烟道着火时，烟气直接通过烟囱排入大气，关闭通往冷却塔和旁通风机的阀门。上述烟道阀门的开启与关闭，均通过自动控制系统，由电动或启动执行机构自动执行。温度信号是由设在冷却塔入口及出口、两条副烟道阀门前、电捕内的热电偶采集，当焙烧炉出口烟气温度高于 250℃或低于 90℃时，系统会发出报警信号。